By Cathy Hansen
contributing writer 

Mojave Air & Space Port – then and now, part 2

Short Flights

 

September 17, 2022

Gary Childress

QF-86E

Mojave Airport starts to grow in the 1970s and 1980s -

Several small businesses were already established at Mojave Airport, but the major lessee was the General Electric Engine Test facility. They had recently moved from Edwards Air Force Base to Mojave Airport and they employed 100 people.

One of GE's first engine flight test programs in 1971 at Mojave was a North American Sabreliner fitted with GE engines that provided 200 pounds more thrust than the original engines. Later they used a Boeing 707 and then a Boeing 747 that tested the GE-90-115 engine that was used on the Boeing 777.

Airport Growth continues

Flight Systems Inc. (FSI) was founded at Newport Beach, California in 1968 by Bob Laidlaw, an MIT graduate with an advanced degree in Aeronautical Engineering. In acquired the assets of Long Beach-based Flight Test Research, among these being a Canadair Sabre 6 (N186F) and four Canadair T-33 Silver Stars. These aircraft went to equip FSI's new flight test operation in Mojave, California. The flightline was full of FSI's F-86s, T-33s, F-100s, some A-4 Skyhawks and later F-4s.


FSI's primary business was to assist in the development of surface-to-air missiles for the U.S. Army. The Stinger missile and the Patriot missile systems are two of the more successful projects Bob's company participated in.

An initial FSI drone proposal was submitted to the U.S. Army Targets Branch at Huntsville in December 1973, and a "proof of concept" contract was signed a year later. Concurrent with the agreement, Laidlaw was able to secure a purchase option on approximately 55 of Dave McEwen's ex-RCAF Canadair Sabre Mk5 airframes.


The Loop Digital Network

The U.S. Air Force required the drone system be designed with the same redundancy as a missile system. They required the ejection seat to be removed, so then no pilot could fly the aircraft. However, to ferry the aircraft to another location made it necessary to re-install the ejection seat and all equipment for a pilot to fly it, which added tremendous expense.

FSI took a different tack: the company thought that if the drone conversion could be kept simple, and the drone was never flown without a safety pilot except for actual missile firings, then the probability of losing an aircraft due to system failure would be very low. As a result, the QF-86E conversion could be relatively simple and would thus minimize cost. Minimum disruption of the aircraft systems also ensured that the conversion process was quick and easy.


In the Loop -  A Tehachapi Podcast

Flight Systems aerial target program was acquitted by Tracor, Inc. in 1981 and later BAE Flight Systems took over the aerial target/drone business.

From 1996 to 2013, BAE Systems, converted McDonnell Douglas F-4 Phantom jets to full scale, remotely controlled aerial targets that the Air Force used for weapons testing and aircraft training at Tyndall Air Force base in Florida or Holloman AFB in New Mexico.

Canadair Challenger 

In the 1970s, the new Canadair Challenger business jet on the drawing board was a risky proposition. Derived from a design by American inventor and aircraft developer Bill Lear, Canadair Chief Designer Harry Halton married a wide-body fuselage with a high performance supercritical wing and state-of-the-art engines. With banks and the then federal Minister of Industry, Trade and Commerce Jean Chretien requiring 50 "firm orders," a Canadair sales team was dispatched to sell a "paper aircraft with only sales brochures, scale models and a wooden mockup to go on."


Read Past Issues of The Loop Newspaper, Online!

The innovative Challenger design boasted industry-leading performance. It promised to be faster, cheaper to fly and more comfortable than any other business jet.

With orders of 56 aircraft from North America, Europe and the Middle East, Canadair's top management, headed by Frederick Kearns, gave a "go" to the Challenger project.

Guess where they wanted to do all of the flight test work to gain certification for worldwide operation? The first prototype was flown to Mojave Airport and Dan Sabovich saw to it that a hangar was especially constructed for them. It is still known as the Canadair hangar, just east of the Administration Building.


National Test Pilot School

The National Test Pilot School, located at the east end of Mojave Air & Space Port, was established in 1981 and is the only civilian test-pilot school in the United States. It is organized as a not for profit, educational institute under California state law and is governed by a board of trustees.

NTPS is one of the seven test-pilot schools worldwide recognized by the international Society of Experimental Test Pilots, giving pilot graduates of NTPS instant initial acceptance into their society. 

In 2016, NTPS became the first test-pilot school in the world to be certified as a Flight Test Authorized Training Organization by the European Aviation Safety Organization.

Rutan Aircraft Factory & Scaled Composites

Burt and Dick Rutan – So many airplanes and so many records!

Burt Rutan Designs

Burt Rutan, without a doubt is the most prolific aircraft designer in the world! I have to mention some of his first designs (too many to picture) for the Rutan Aircraft Factory, including: Variviggen; VariEze; Defiant; Quickie; Long-EZ; and Solitaire. Rutan went into design overdrive after he formed Scaled Composites!

The Rutan Aircraft Factory operated from 1974 to 1985 selling airplane plans developed by Burt and supporting home builders. During those 11 years, Burt developed a total of 12 different aircraft, the most notable of which is the Long-EZ.

In August 1982, Rutan broke ground for his new 30,000-square-foot building to house his new business, Scaled Composites. The ground-breaking ceremony had Mojave Airport General Manager, Dan Sabovich, holding a composite shovel digging out the first dirt for the project, as Scaled Composites President, Burt Rutan and Vice President, Herb Iverson looked on.

This year Scaled Composites will observe their 40th anniversary of designing, building and testing composite aircraft.

The success of Scaled Composites owes itself to Burt's philosophy that the best ideas come from the collaborative efforts of small, closely-knit project teams and an environment unlimited by adversity to risk. Although Burt officially retired from Scaled in 2011, his legacy continues in Mojave.

In August 2007, Northrop Grumman completed a transaction that increased its ownership in Scaled Composites, LLC from approximately 40% to 100%.

Rutan Voyager Flies around the World, non-stop – unrefueled

Rutan, famous aircraft designer and former CEO of Scaled Composites, created Voyager for maximum fuel efficiency. Crew Chief Bruce Evans and a host of volunteers built this graceful design at Mojave Airport in Hangar #77.

Voyager made the extraordinary first-ever non-stop, unrefueled flight, around the world with pilots Dick Rutan and Jeana Yeager (no relation to Chuck Yeager).

The circumnavigation flight was 26,366 statute miles, which more than doubled the previous record set by a B-52 Bomber in 1962. This fragile aircraft with a wingspan of 110 feet had an empty weight of only 939 pounds. The gross weight on take-off from Edwards AFB, December 14, 1986, was 9,694.5 pounds.

The milestone flight took nine-days, three-minutes and 44 seconds and the absolute world distance records set during that flight remain unchallenged today.

Thousands of people witnessed the landing of Voyager on Dec. 23, 1986 on the dry lake bed at Edwards AFB. The Voyager story is one of great emotion, courage, vision and adventure and is often referred to as "aviation's last first."

Starship POC (proof of concept)

On Aug. 25, 1982, Beech had contracted with Scaled Composites to refine the design and build an 86% scale POC (proof of concept) aircraft. One of the significant changes made to the design by Scaled Composites was the addition of variable geometry to the canard.

On August 29, 1983, less than a year after the founding of Scaled Composites, Burt's brother, Dick Rutan, piloted the Starship prototype.  Beech Management flew in to Mojave from Wichita, Kansas to witness the first flight of the airplane they hoped would replace their King Air.  

Alan Radecki

From 1996 to 2013, BAE Systems, converted McDonnell Douglas F-4 Phantom jets to full scale, remotely controlled aerial targets.

Part three will tell about the growth that took place in the 1990s and will be in a future issue of The Loop newspaper.

 
 

Powered by ROAR Online Publication Software from Lions Light Corporation
© Copyright 2021

Rendered 09/27/2022 01:37